,
(Prepared According to 29 CFR 1910.1200) Date Prepared: February, 1999 Date Revised: September,
05
Prepared by: Robert V. Johnson Date Printed: September 11, 2005
|
SECTION 1 - COMPANY &
PRODUCT IDENTIFICATION: |
|
Company
Name: KLEERWITE CHEMICAL Emergency Phone:
800-535-5053 (InfoTrac) |
|
P. O. BOX 10428, BURKE, VA 22009-0428, 703-451-3964; FAX: 703-451-7362 |
|
Trade Name: RUST BUSTER Product Type: STAIN REMOVER |
|
SECTION 2 - INGREDIENT INFORMATION: THE INGREDIENTS IN THIS PRODUCT ARE
CONSIDERED PROPRIETARY. IN CASE OF
EMERGENCY CONTACT InfoTrac. |
|
SECTION 3 - HEALTH HAZARD DATA: |
|
Primary Routes of Exposure Eye[ X ] [ X ] Skin [ X ] Oral [ ] Inhalation [ ] Other |
|
Overexposure Effects: MAY CAUSE CHEMICAL BURNS! May cause respiratory irritation, osteofluorosis, and respiratory impairment. May be fatal if swallowed. Corrosive to the eyes. |
|
Threshold Limit Value: Not Established. |
|
H.M.I.S Values: Health (Blue) - 3 ; Flammability (Red) - 0; Reactivity (Yellow) 0; Personal Protection - D |
|
Carcinogen or Suspect Carcinogen Ingredients [ ] NTP [ ] IARC [ ] OSHA [ X ] None |
|
SECTION 4 - FIRST AID
MEASURES: |
|
Eyes: Remove contact lenses. Immediately flush eyes with water for 15 minutes get prompt medical attention. |
|
Skin: Flush skin with water. Remove contaminated clothing and wash before use. |
|
Ingestion: Rinse mouth at once, then drink 1 or 2 glasses of water or milk. DO NOT induce vomiting. NEVER give anything by mouth to an unconscious person. Get medical attention. |
|
Inhalation: Seek well ventilated area. Seek immediate medical attention. |
|
SECTION 5 - FIREFIGHTING MEASURES: |
|
Flash Point (T.C.C.) [X ] None to boiling Flammable Limits Upper: Not Flammable ; Lower: Not Flammable |
|
Extinguishing Media: BC/ABC Extinguisher may be used in area where material is stored. |
|
Special Firefighting Procedures: Wear self-contained breathing apparatus. |
|
Unusual Fire and Explosion Hazards: In case or fire, highly corrosive gasses may be emitted. |
|
SECTION 6 - ACCIDENTAL RELEASE MEASURES: |
|
If Released or Spilled: Stop leaks. Contain spill; absorb with an inert material and place in a suitable container. Flush spill area with large amounts of water. |
|
Waste Disposal Methods: Dispose of wash water and spill byproducts according to State and Federal regulations. |
|
SECTION 7 - STORAGE AND HANDLING INFORMATION: |
|
Store in a cool, dry area. Do not allow product to freeze. Do not get in the eyes, on skin or on clothing. Do not take internally. |
|
SECTION 8 - SPECIAL PROTECTION INFORMATION |
|
Respiratory Protection: Not needed under normal condition of use. |
|
Ventilation Requirements [ X ] Local Exhaust [ ] Mechanical [ ] Other |
|
Protective Gloves: Necessary for any contact. Eye Protection: Chemical goggles. Other protective Clothing: Recommended. |
|
SECTION 9 - PHYSICAL AND CHEMICAL PROPERTIES: |
|
Boiling point (0F.) Above 200°F Density (lb/gl) 8.659 Specific Gravity (H2O = 1) 1.038 pH (1%) = >4.5 |
|
Vapor Pressure (mm Hg) <0.01 mm Hg Vapor Density (Air=1) >1.0 |
|
Solubility in water: [X ] Complete [ ] Insoluble [ ] Emulsifiable (or Dispersible) [ ] Slight (or Partial) |
|
Evaporation Rate (vs. Ether) [ ] Faster [X ] Slower [ ] About the same |
|
Appearance and Odor: Clear liquid with an acrid odor. |
|
SECTION 10 - STABILITY AND REACTIVITY: |
|
Stability: Stable. Incompatibility: Glass, silicon compounds; alkalis. Hazardous Decomposition Products: Highly corrosive fumes. |
|
SECTION 11 - TRANSPORTATION INFORMATION: |
|
Proper Shipping Name: CONSUMER GOODS, O.R.M. - D |
|
D.O.T. Hazard Class: ORM-D UN Number: N/A Packaging Group: III Label Required: ORM-D |