,
(Prepared According to 29 CFR 1910.1200) Date Prepared: June, 1998 Date Revised: September
11, 2005
Prepared by: Robert V. Johnson Date Printed: September 11, 2005
|
SECTION 1 - COMPANY &
PRODUCT IDENTIFICATION: |
|||
|
Company
Name: KLEERWITE CHEMICAL Emergency Phone:
800-535-5053 (InfoTrac) |
|||
|
P. O. BOX 10428, BURKE, VA 22009-0428, 703-451-3964; FAX: 703-451-7362 |
|||
|
Trade Name: ACETIC ACID - 28% Product Type: BASIC CHEMICAL |
|||
|
SECTION 2 - INGREDIENT INFORMATION:
* = HAZARDOUS |
|||
|
CHEMICAL NAME/COMMON NAME |
CAS NO. |
PERCENT |
TLV |
|
* ACETIC ACID - GLACIAL |
64-19-7 |
25 - 30% |
3 mg/m3 |
|
WATER |
7732-18-5 |
|
|
|
SARA HAZARD TITLE III, SECTION 313-CONTAINS THE STARED
INGREDIENT(S) AT THE INDICATED PERCENTAGES |
|||
|
SECTION 3 - HEALTH HAZARD DATA: |
|||
|
Primary Routes of Exposure Eye[ X ] [ X] Skin [ X ] Oral [ X] Inhalation [ ] Other |
|||
|
Overexposure Effects: Causes severe eye and skin burns and irritation. Ingestion will cause mucosal damage. |
|||
|
Threshold Limit Value: Not Established. |
|||
|
H.M.I.S Values: Health (Blue) - .3 ; Flammability (Red) - 0; Reactivity (Yellow) - 1; Personal Protection - C |
|||
|
Carcinogen or Suspect Carcinogen Ingredients [ ] NTP [ ] IARC [ ] OSHA [ X ] None |
|||
|
SECTION 4 - FIRST AID
MEASURES: |
|||
|
Eyes: Remove contact lenses. Flush eyes with water for 15 minutes, get prompt medical attention. |
|||
|
Skin: Flush skin with water. Remove contaminated clothing. |
|||
|
Ingestion: Give several glasses of water or milk. NEVER give anything by mouth to an unconscious person. Get medical attention.. |
|||
|
Inhalation: Seek well ventilated area. If irritation persists seek medical attention. |
|||
|
SECTION 5 - FIREFIGHTING MEASURES: |
|||
|
Flash Point (T.C.C.) [X ] None to boiling Flammable Limits Upper: Not Flammable ; Lower: Not Flammable |
|||
|
Extinguishing Media: Foam, CO2, Water fog, BC/ABC Extinguisher may be used in area where material is stored. |
|||
|
Special firefighting Procedures: None known |
|||
|
Unusual Fire and Explosion Hazards: None known |
|||
|
SECTION 6 - ACCIDENTAL RELEASE MEASURES: |
|||
|
If Released or Spilled: Stop leaks. Contain spill, absorb with an inert material and place in a suitable container. Flush spill area with large amounts of water. |
|||
|
Waste Disposal Methods: Dispose of wash water and spill byproducts according to State and Federal regulations. |
|||
|
SECTION 7 - STORAGE AND HANDLING INFORMATION: |
|||
|
Store in a cool, dry area. Do not allow product to freeze. Do not get in the eyes, on skin or on clothing. Do not take internally. |
|||
|
SECTION 8 - SPECIAL PROTECTION INFORMATION |
|||
|
Respiratory Protection: Not needed under normal condition of use. |
|||
|
Ventilation Requirements [ X ] Local Exhaust [ ] Mechanical [ ] Other |
|||
|
Protective Gloves: Necessary for any contact Eye Protection: Safety glasses/goggles Other protective Clothing: None needed |
|||
|
SECTION 9 - PHYSICAL AND CHEMICAL PROPERTIES: |
|||
|
Boiling point (0F.) Above 200°F Density (lb/gl) 8.435 Specific Gravity (H2O = 1) 1.011 pH (1%) = 2.9 |
|||
|
Vapor Pressure (mm Hg) 15.7 mmHg Vapor Density (Air=1) 2.07 |
|||
|
Solubility in water: [X ] Complete [ ] Insoluble [ ] Emulsifiable (or Dispersible) [ ] Slight (or Partial) |
|||
|
Evaporation Rate (vs. Ether) [ ] Faster [X ] Slower [ ] About the same |
|||
|
Appearance and Odor: Clear liquid with a pungent acidic odor. |
|||
|
SECTION 10 - STABILITY AND REACTIVITY: |
|||
|
Stability: Stable Incompatibility: Oxidizers and alkalis. Hazardous Decomposition Products: None known. |
|||
|
SECTION 11 - TRANSPORTATION INFORMATION: |
|||
|
Proper Shipping Name: ACETIC AID SOLUTION |
|||
|
D.O.T. Hazard Class: 8 UN Number: UN2790 Packaging Group: PGII Label Required: CORROSIVE |
|||